Low fluid levels on Fords to save a few bucks?

[hoodscoops]

Besides the oil levels, did anyone else check their differential/coolant and other misc fluid level. It seems like Ford is intentionally put the fluid levels slightly less than their recommended. My other family members bought an explorer and bronco and they all noticed their levels are slightly below average. Im guessing this is Fords way to save a few bucks.

Sponsored

 

[Will2]

My 2024 Mustang Ecoboost was low on coolant (and maybe a slow leak?), traded in for a 2025 Mustang GT and took pictures of the starting coolant and oil levels after I got back from the dealership, mostly for monitoring purposes. The levels were OK on this one

 

[MAT1955]

@hoodscoops ...... This is the dealer's fault for not doing a proper PDI. I have been told by my brother-in-law, who was an automotive engineer for GM that they ship the levels slightly low on purpose as they cannot control temperature (expansion) and level at the factory - too high a fill is not good. Also, of importance, it is far easier and cheaper for the dealer to top up a level than to reduce (drain) one.

 

[hoodscoops]

@hoodscoops ...... This is the dealer's fault for not doing a proper PDI. I have been told by my brother-in-law, who was an automotive engineer for GM that they ship the levels slightly low on purpose as they cannot control temperature (expansion) and level at the factory - too high a fill is not good. Also, of importance, it is far easier and cheaper for the dealer to top up a level than to reduce (drain) one.

This is for transmission fluid too? the Explorer forums have been posting that it cam from the factory low.. I dont buy it. This is 2025 and this seem to be a ford thing only. They are trying to save a few bucks by not topping of their fluids

 

[MAT1955]

@hoodscoops ..... yes - I would certainly expect the transmission to be properly filled from the factory. I have not heard of one that was underfilled but there's lots I haven't heard of. On my 2014 Mustang checking the tranny oil was a pita. It had to be done hot and you had to be very careful to not break the plastic dip stick and then rest it atop the fill hole for a proper reading. Much easier done at a dealership.

 

[Gregs24]

Underfilling would not save money it would cost money in warranty claims!

Sponsored